OKA Spare Parts And Suppliers.

OKA Parts and Technical Advice

OKA, Kalgoorlie

Robin Wade maintains OKAs in the Goldfields (good bloke, parts and repairs and sound advice, a true gentleman!) 08 9091 6195.
Or

East Coast OKA's

Paul Nott, has most parts available, carries heavy duty running gear such as 35 spline axles and steering knuckles, bearings rebuild kits, Engine cold start units, etc, excellent customer service and advice, very knowledgeable great bloke available 24/7 Mob:0418-125428
Or

OKA Factory

Technical advice and Parts are available from OKA Direct, Bibra Lake (Perth) 08 9434 1300, ask for Angelica (very helpful & knowledgeable).
Or

Intune Automotive (Previously Don Kyatt Motors, before that, Fiddler & Clarke)

Now owned by Katherine & Steve Golding (May 2008).
275 North Stewart Highway, Alice Springs (same address) Ph: 08 89 534 322, email: alicemechanical@bigond.com
(Good people, just as keen and attentive)

Note:
Try Robin Wade from OKA Kalgroolie, or Paul Nott from East Coast OKA's first between them they have a huge range of parts so you should be able to source anything you need in the shortest time possible. Some items are more than 50% cheaper than from the OKA Factory.

Engine Cold Start Kit

If you Engine has problems Cold Starting then Contact Paul Nott for one of his Cold Starter Units, Works Very Well

Grease

Grease type LE 3752 expensive! Doesn't get displaced, hangs on and does not emulsify with water. Cantankerous to wash off, WD40 cleans it off your hands.
Lubrication Engineers Pty Ltd, Prospect, NSW, (02) 9636 5655 Allan Green
Or:
Yamalube Marine grease sticks like shyte to a blanket) high quality marine grade, I have used this grease on off road motorcycles including in competition for several years in conditions that would kill an OKA (or any other 4WD) stone dead and it is a seriously top rate product as are all other Yamalube (Yamaha) products I have used over the past 30 years or so.

Oil

Engine Oil:
Castrol RX

Hydraulic Oil (Power Steering):
Castrol Transmax M,

Diff, Front and Rear:
Castrol LSX90,

Uni Joints

Steering 5 332 X Spicer No.
Make sure they have a grease nipple this No. joint should have.

Tail Shaft K5 GB10RHD
Again these ones have grease nipples and heavy duty seals.

I recommend you carry both these Uni-Joints as spares.

Both these Uni joints are available from:

Truckline, Wetherill Park, NSW (02) 9729 3700

Truckline Virginia in Brisbane (make Trevor a believer) got tie rod ends from these guys. Once pushed a bit they will try hard and get what you need. Airfreighted parts at no great expense.

The real heros though were Whitehorse trucks in Morewell Vic whom Truckline phoned to confirm part numbers etc (Whitehorse have been known to supply parts to OKA in WA first class svc so stick with these guys) some of you will already know all about this so I leave out the details.

Grab Handles

Inside cabin (black), secured by 4 screws, also other OKA Locks & Catches

Universal Engineers Supplies: http://www.uesint.com (cache)
2/42 Birnie Avenue, Lidcombe NSW 2141 (02) 8745 9000
16 Tikalara St, Regency Park, South Australia, 5010 (08) 8340 1599
38 - 40 South Link, Dandenong, Victoria, 3175 (03) 8787 3100
4/ 5 Bishop St, Stuart Park, Northern Territory, 0820 (08) 8946 4500
8 Boulder Rd. Malaga, Western Australia, 6090, (08) 9249 2211
1-3/36 Pritchard Road, Virginia, QLD, 4014, (07) 3865 5600

Front Side Blinker Lights

I find blinkers continually get smashed off in the scrub.
Order through Repco - OKA tail lights, mirrors etc.
Britax Part No. 10430.01 (Blinker Lights) these blinkers use a small cap less bulb.

Drive Shaft Repairs

Diff & Gear Box, yokes, slip joints etc & modifications, also balancing.

Hardy-Spicer

For Tail Shaft Repairs
http://www.hardyspicer.com.au (cache)

1. 10/ 30 Heathcote Rd, Moorebank, NSW, 2170 (02) 9600 6333, Colin Hancock
2. 56 -58 Churchill Rd North Dry Creek, South Australia, 5094 (08) 8349 6400
3. 1/9 Monterey Road, Dandenong South Victoria, 3175 (03) 9792 4744

Air Conditioner

G,day we have evaporator coils to suit XT front aircon, dual & multi cab aircon, not sure about LT front need to check with OKA.
Part No EV-3380.
Rodney Lyons, OKA Owner And Member
Lyons Airconditioning Services (WA)
rlyons@lyonsaircon.com.au
www.lyonsaircon.com.au
08 9453 2811

Gear Box

The part number for the Oka gearbox is: Spicer: T5290
Kowari Motors
10 Trade Court,
Bohle Industrial Estate
Townsville, Qld 4818
Ph: 07 4774 7577
Fax: 07 4744 4946
email:admin@kowarimotors.com.au
Website:www.kowari.com.au

Rear Gearbox Mounting Rubbers

Mr Lloyd parsons mechanic recognised the part as being the early Landrover and that they would be heaps cheaper then OKA's pricing. Landrover part numbers are not know at this stage.

Gear linkages

Rod ends: part number BL12BD from CBC Bearings, about $19 each. Ensure they have M12 threads with 1.75 pitch. Note later Oka's (after Vin 137) may have different rod end types and sizes.
There are 4 rod ends, 1 on the transfer shaft and 3 on the gearbox shaft. The one attached above the bell housing is difficult to access but is probably not worn anyway since it only acts as an anchor point. Most pivot pin holes on linking bars were elongated due to vibration. Weld up and re-drill the correct size or pack with shim material.
Replace all clevis pins and fit washers between the moving parts to minimise lateral movement. Movement causes noise and wear. Grease everything well.

Springs

Front & Rear, Shockers, Resets, Alterations, Modifications, extra leaves.
Setting the old fashioned way, A true professional.

Southern Cross 4WD
1385 Burragorang Road, Oakdale, NSW, (02) 4659 6316

Brisbane Springs (they have detailed files!) but I bought the last of the shackle pins and bushes they had. Still they know how to get dem OKRE parts and are a very professional outfit. Speak to Geoff King and Tell em Nols sent ya)

Diff Repairs

Modification, resetting

D & R Diff Repairs
Chipping Norton, (02) 9755 4357, Forget the rest give Glen a ring.

Front and Rear Axles

Left & right hand standard 32 spline rear axles in stock for OKAs!!! Will make oversize axles 35 spline to suit OKAs with modified rear diffs. Makes them on the premises! Good bloke. Axles must be replaced in pairs after a breakage!

Anthony Natoli Enterprises, Hoxton Park, NSW (02) 9607 2092

32 & 35 spline front inner/outer and rear axles in standard or chromoly generally always in stock together with crown wheel & pinions, LSD kits etc . Also developing Dana 80 axle assemblies available shortly, from Eastcoast OKA, Paul Nott Mob:0418-125428

Drive Belts

For Air Conditioner Alternator, Window Winders (front doors)

Belt Part No. Air con 9425 13A1080

Alternator 9520 13A1320

Window winder 510L0507250DS

Carry ALL belts as spares

I have found Gates Green Stripe Belts the most serviceable, available from:

R. P. WALLIS, Unit 2, 158 Newton Road, Wetherill Park, NSW, Phone (02) 9756 5111

Also Try Mick's Truck Bits in Capalaba (Bris-Vegas) Mick is very savvy in the truck biz and can find parts at a reasonable price. He has helped me out a bit and once he got a handle on OKA's (helped by having mine parked in his doorway(all of his doorway) he has been able to source most of the stuff listed here at good prices (including a bigger badder jack- 10 tonner of same quality for price of the 6 tonner since no 6 tonners were available that day!) 20L of Castrol RX for $72.00.and all filters supplied at less than quoted several dealers elsewhere.

Air Filters

Primary: DONALDSON Part No. P133765
Secondary: DONALDSON (safety) Part No. P136401

Engine Oil Filter

Donaldson Part No. P554407
or
FLEETGUARD, No L.F.699

Hydraulic Oil Return Line Filter

Donaldson Part Number: P550162
or
RYCO, Z79A

Fuel Filters

1st Filter Element only FLEETGUARD, FS 1240
1st Filter Sediment bowl & filter element (both parts) FS 1240B

Note, Next (filter) is a fuel sediment and water bowl only and needs inspection and draining and cleaning when necessary.

Fuel Filter On Engine

Donaldson Part No. P557111
or
Perkins No. 26561117 Power Part
or
Fleetguard No.FF167A


For All Donaldson Filters Contact:
http://www.donaldsonfilters.com.au/homepage/home.asp (cache)

Wheel Bearings (LT&XT)

Front Inner cup 382A
Inner cone 387A

Outer cup LM 104911
Outer cone LM 104949
(Timken Set 38)

Rear Inner cup 45220
Inner cone 45291

Outer cup LM 104911
Outer cone LM 104949
(Timken set 38)

Note: All "DAN....." Part Numbers Listed in the OKA Parts Manual Can Be Converted By CBC Bearings as they are a Genuine Dana Part Number and are Listed on their Conversion Charts

Rear Hub Seal

National Federal Mogul 415086N
or CR30055
Speedie sleeve CR99300

Front Hub Seal

Size 2.750*3.875*0.500

Inner Diff Seal and guide

NOK 36487-1

King pin Bearing

Cone 23100
Cup 23256

Front and Rear Diff Pinion Seal

National Federal Mogul 9316
or CR18888

XT Transfer Case Front Output
Speedie sleeve CR99212
Seal CR27467 (2 can be fitted)

XT Transfer Case Rear Output
Speedie sleeve CR99087
Seal CR TC12141

Temperature Sensor Unit

VDO 320.031

XT Speedo sensor

TURCK # BI8U-M18-AN6X Available from Micromax 1300 326 626 approx $150 Plus GST Plus frieght.

Steering Box TRW

New TRW Steering Boxes and Rebuilds (To NT Standard)

Australian Importers of TRW Boxes and Seal Kit, Workshop Facilities For Rebuilds:
Complete Steering Australia Pty.Ltd.
U 1/ 55 Cherry La Laverton North 3026 Phone (03) 9369 2659

Steering Damper

Powerdown Steering Dampener, Part no: SS-2716.
http://www.powerdown.com.au/ (cache)
Contact: Gus Dalfarra, gus@powerdown.com.au for your nearest Outlet, Let him Know you are from the OKA Owners Group For a Good Price.

In Sydney: Wholesale Suspension, 129 Coreen Ave, Penrith NSW 2750
Phone:02-47212 112 Fax:02-47217 977

In South Australia Contact:
Safety Steer, 22 White Road, Gepps Cross, South Australia, Phone: (08) 8349 6364,

Ball Joints etc

K.S.A. Truck Parts & Repairs Pty Ltd , 1 Moore St Leichhardt 2040(02) 9692 8222
Truckline Truck & Trailer Parts, Lot 3 Ormsby Pl, Wetherill Park 2164
ph:(02) 9729 3700

Shock Absorbers

Monroe, Magnum 60 Gas Shock Absorbers, Front and Rear, Part Number 66638

Jack

(Hydraulic) Ideal for OKAs as it has a 2 stage lift 250mm (2 rams) to raise high profile tyres clear of the ground with ease!! Also has a 75mm high screwed section so minimum packing is required. Its capacity is 6000kg safe working load

Ring Jutco Pty Ltd, Unit 1 30/34 Maffra St, Colaroo, Vic 3048, Phone 1300 133 921 for the agent closest to you Jack Part No. 60113 Price around $110.

Water Pump

Water pump and any engine spares try Geoff Walsh
on your engine parts requirements telephone our Engine Parts Hotline on
1800-810-507 Australia -Wide or EMAIL sales@gwengineparts.com.au

Sydney:
EIP Diesel P/L, 37 Eddie Road, Minchinbury NSW 2770, Phone: (02) 9675 3444, Mark Brentnall Email:eipdiesel@tpg.com.au

15 Chain Street, Mackay, Queensland AUSTRALIA 4740 P.O.Box 555, Mackay, Queensland AUSTRALIA 4740 Telephone +61 7 4951 3177 Fax 07 4951 4020

Perkins 100 Series Motor Parts

Sydney:
EIP Diesel P/L, 37 Eddie Road, Minchinbury NSW 2770, Phone: (02) 9675 3444, Mark Brentnall Email:eipdiesel@tpg.com.au

Adelaide:
A W Diesel Repair Services, 12 Fifth St Wingfield, South Australia, 5013, (08) 8347 0083

Locking Hubs

The freewheeling hubs are AVM
(made in Brazil, see http://www.avm.com.br/products4.htm (cache)),
Model No. 439 for Dana 60 axles with internal mounting. I got them from ARB Adelaide who were cheapest ($213 a pair for Oka Owners Group).

AVM also sell a "Service Kit" at ~$40, but it only contains oil seals and circlips, not any of the breakable parts inside, which is what I needed

Starter Motor

Compact gear reduction model available through East Coast OKA
XT196 (Peter & Margaret Wright, South Australia) fitted a UNIPOINT B/N 4981, UN10409, 01-71895, STR-6078A, Perkins mount.

Alternator

LT Bosch BXU1285A
Note: Alternator needs a tacho signal pick-up...

Keys

Ignition key Silca blank number NE38.
Door key Silca blank number V01.
See Your Local Locksmith

PARTS & EXTRAS

Dingoseatcovers.com.au http://dingoseatcovers.com.au/index.html (cache) Ph 07 40955661 have canvas seat covers available for the OKA seats. We own OKA 072.
Northside 4x4 accessories (ARB Caboolture) Ph 07 54955519 have bolt on waste gated turbos and glycol intercoolers for the Perkins Phaser. This gives the engine full boost at low revs and means that the OKA's can now overtake safely.
Boss air suspension http://users.bigpond.net.au/rta89255/index.htm (cache) Ph 07 5641 0174 have tripple bellows air springs suitable for the very long OKA wheel travel. These compared to Firestone are tough and cheep.
Fulcrum http://www.fulcrumsuspensions.com.au/ (cache) have just finished developing a eurothane spring bush kit for the OKA's.